KTM P4-75-D600-PTFE

KTM P4-75-D600-PTFE

KTM P4-75-D600-PTFE

KTM P4-75-D600-PTFE 深度不準，在大鉤上下運行時，同樣的距離測的絞車脈沖不一樣，顯示下行或上行速度不一致，甚至出現深度有跳變現象。
1) 首先判斷軟件方面：查看絞車傳感器的基本數據，即大鉤高度參數：滾筒直徑、層圈數、層數、大繩股數、終圈數、大繩直徑等是否與實際相符，如不相符將會造成深度誤差。故障排除：將大鉤高度參數按實際設置。如果軟件設置沒有問題再判斷硬件方面。
2) 接口方面：假如大鉤上行、下行都能采集到數據，一般模塊沒有問題；如果其間曾經更換或設置過模塊，可能模塊設置錯誤：
⑴采集速率不對
⑵脈沖脈寬、峰高設置不恰當
⑶模塊阻抗不匹配都會產生丟失脈沖現象。
故障排除：⑴設置模塊采集速率；
⑵重新設置脈寬和峰高（一般高電平為2.4V低電平為0.8V）；⑶更換采集模塊。
3) 傳感器方面：
故障判斷：絞車傳感器有問題
⑴線路有虛接或短路現象
⑵傳感器感應體臟污使感應信號紊亂。
故障排除：
⑴檢查線路接頭，確保接觸良好，有時鉆井隊打掃衛生會使線路接頭進水而產生弱短路，可用萬用表測量供電電壓是否是+5V；
⑵拆卸傳感器，清除內部鐵銹和臟污；
⑶更換絞車傳感器。
GE FANUC IC693CPU364 IC693CPU364 EK FK
TOTAL CONTROL GE FANUC QPK3D200S2P QPK3D200 QUICKPANEL EXC COND
GE FANUC IC660ELB906R IC660ELB906 INTF MOD
GE FANUC IC670GBI002 E J IC670GBI002
TOTAL CONTROL GE FANUC QPK2D100S2P QPK2D100 QUICKPANEL MAN REF
GE FANUC IC800SLA1002B IC800SLA1002 IC800 NEW
GE FANUC PROFACE GP377 SC41 24V 2880011 01
GE FANUC DS3815PIOA1C1A1 DS3815PIOA1C DS3815PIOA1C DS3815PIOA1 DS3815PIOA DS3815
GE FANUC 531X111PSHALG3 531X111PSHAL 531X111PSHA 531X111PSH 531X111
GE FANUC 531X111PSHAWG2 531X111PSHAWG 531X111PSHAW 531X111PSHA 531X111
New Grundfos Multistage Centrifugal Pump CRN3-11 A-FGJ-GI-E-HQQE 2 HP
TOSHIBA X-RAY Image Intensifiers E5844H-P1K
FANUC A06B-6066-H012 AC SERVO AMPLIFIER
ADVANTEST R3463 MODULATION SPECTRUM ANALYZER W/ OPTS & R3561L CDMA TEST SOURCE
Advantest R6740B Power Source
Novellus 02-132030-00 ASSY,MOD,CTR,P166/64/QNX4 controller
Bosch Rexroth Versorgungsger?t HMV01.1E-W0030-A-07-NNNN GEB
Axialkolbenpumpe Bosch Rexroth A10VSO28DFR1/31R-PPA12N00 R910910590
SOUTHCON PHENIX INC. SAFTRONICS DC12 10-30HP NEW! TESTED! REGENERATIVE DC DRIVE
NEW! SOUTHCON PHENIX SAFTRONICS DC12 REGENERATIVE 30HP DC DRIVE TESTED QUANTITY!
Advantest Spectrum Analyzer TR4172, RF Section, Powers On, OPT: 01, 04, 06,
FANUC A06B-6127-H207 SERVO AMPLIFIER MODULE
FANUC A20B-1003-0010/15B CIRCUIT BOARD
Advantest R3267 100Hz-8GHz Spectrum Analyzer Rack8c
Advantest R3465 Spectrum Analyzer, 9Khz-8Ghz, Calibrated with Warranthy
ADVANTEST R6243 110V 2A DC Voltage Current Source/Monitor
Advantest R3465 Spectrum Analyzer, 9Khz-8Ghz, Calibrated with Warranthy
MA4/200-7101-M Bosch REXROTH Gebraucht/Used
GE FANUC A20B-2902-0373/02A A20B-2902-0373 NEW
GE FANUC A20B-8001-0700/02B A20B-8001-0700 RIO INT. NEW
GE FANUC 90-70 602199 104 DELTA TAU 602705 602200
GE FANUC DS3800HXRB1D1D DS3800HXRB1D1 DS3800HXRB1D DS3800HXRB1 DS3800HXR DS3800
Bosch REXROTH Servomotor MDD0112C-N-015-N2M-180GB0 MDD0112CN015N2M180GB0 REM
HP Agilent E4432A ESG RF Signal Generator, 1E5 UN3, Calibrated with Warranty
HP/Agilent E4432A ESG-D Digital RF Signal Generator, Calibrated with Warranty
Bosch 0811-404-174 Rexroth 4WRPH6C3B40L-2X/G24Z4/M-561 Valve New w/Warranty
Advantest U3641 Spectrum Analyzer 9 kHz to 3 Ghz
Advantest D33711 Clock Recovery Unit